Full Box (780) DUO CLAMSHELL Plastic Boxes. VAT Included.

Full Box (780) DUO CLAMSHELL Plastic Boxes. VAT Included.

Stock Status: In Stock
£195.00
You Will Earn 195 points with this purchase

Product Information

Our DUO CLAMSHELL boxes are manufactured in the U.K. and are made of 500 micron plastic. Not only are they 100% recyclable they are also made with 88% recycled plastic. Recycling PET gives a slight tint to the product and depending on the source, you may notice a grey or blue impression however this will in no way detract away from your finished product.

Each box has 6 cavities
but the central dividing wall has been designed taller so that you can create a dual fragrance product without fear of one spilling into the other. They hold approx 85grams of wax at full capacity or you have the option to fill with less. Approx measurements for a closed clamshell are 90 x 71 x 26mm's not including the extra 17mm at the top if you wish to hang your product.


NOTE: Due to the high quality plastic used to make this item and the way they are manufactured, you may on the odd occasion find a tiny hole within the vacuum nodules found on the base of the packaging. This is completely normal and in no way effects how you use this product or the finished result. Due to the viscosity of the wax there will be no spillages and the teeny holes will seal instantly as long as the below instructions are followed.

INSTRUCTIONS: When pouring, make sure your wax temperature is cool and pour slowly. We recommend your wax is no hotter than between 65°C and 70°C but ideally between 55°C and 60°C, anything above this will melt the plastic or find any weak spots. Pour a small amount (5mm) into each individual cell first and allow to start to set, this will check for any flaws. If all is ok, continue to slowly fill the clam. This will minimise the risk of wax spillages. If you see any leakage from the small pour, pop the clam to one side and when the wax is set remove for re use. Please notify us immediately if any problems occur.

DISCLAIMER:

DO NOT separate the clamshells by pulling on the lid. Work them apart at the cavity end.

PLEASE ensure your wax is at the right temperature which we recommend is between 55°C and 60°C. Wax that is too hot will melt the plastic or find any weak spots.

ALWAYS pour on a protected surface.

ANY clamshells that leak will seal rapidly, as long as the wax is poured at the correct temperature, therefore loss will be minimal.

DO NOT discard any spilled wax. Once the clamshell is set, any spilled wax can be melted down and poured back in the top.

IF you have faulty, unusable clamshells, please retain for our inspection.

DO NOT discard clamshells until contacting us first.

  • Condition:
    New